Product ID:MA-25 ABLATIVE COATING TYPE I & II PART C
MSDS Date:07/22/1991
FSC:8010
NIIN:00F040781
Kit Part:Y
MSDS Number: BXMKB

Emergency Phone: 504-257-4125/504-257-2672

Info Phone: 504-257-2672/504-257-4125

Cage: 04939

Telephone: (407) 356-9894

Cage: 53100

HEPTANE

CAS: 142-82-5

RTECS: MI7700000

Fraction By Weight: 100%

OSHA PEL 2000 MG/CUM

ACGIH TLV: 1640 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SLIGHTLY IRRITATING. SKIN:
BURNING. INHALATION: MUCOUS MEMBRANE IRRITATION. TARGET ORGAN
TOXIN-LUNG ASPIRATION HAZARD. INGESTION: MAY RESULT IN ASPIRATION
OF THE LIQUID PRODUCING PULMONARY EDEMA & CHEMICAL PNEUMONITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DEFATTING, BURNING, ITCHING,
NAUSEA, LACK OF APPETITE, LASSITUDE, LIGHT HEADEDNESS, GIDDINESS,
DIZZINESS, LACK OF COORDINATION, RESPIRATORY ARREST, CONVULSIONS,
SEMI-CONSCIOUSNESS, UNCONSC IOUSNESS.

First Aid:EYES/SKIN: FLUSH W/WATER. INGESTION: DON'T INDUCE VOMITING.
OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTE: THIS PRODUCT IS
CONSIDERED AN IMMEDIATE HEALTH HAZARD.

Flash Point Method:TCC
Flash Point:25F
Lower Limits:1
Upper Limits:7
Extinguishing Media:DRY CHEMICAL, FOAM/CO2
Fire Fighting Procedures:EVACUATE PERSONNEL FROM AREA. USE NIOSH
APPROVED SCBA. WATER MAY BE INEFFECTIVE ON FIRE. USE OTHER
PROTECTIVE GARMENTS.
Unusual Fire/Explosion Hazard:HIGHLY FLAMMABLE VAPORS WHICH ARE > THAN
AIR & MAY ACCUMULATE IN LOW AREAS &/FLASH BACK OVER VAPOR TRAIL.

Spill Release Procedures:EVACUATE PERSONNEL FROM AREA. WEAR PROTECTIVE
GEAR. SHUTT OFF SOURCE IF POSSIBLE & REMOVE SOURCES OF IGNITION.
KEEP OUT OF WATER SOURCES & SEWERS. ABSORB IN DRY, INERT MATERIAL.
TRANSFER TO DISPOSAL D RUMS USING NON SPARKING TOOLS.

Handling and Storage Precautions:STORE IN COOL, WELL VENTILATED AREA
AWAY FROM IGNITION SOURCES & DIRECT SUNLIGHT/HEATING SOURCES. KEEP
CONTAINERS CLOSED.
Other Precautions:BOND & GROUND CONTAINERS & PAR/SURFACE RECEIVING THE
ABLATOR MATERIAL DURING LIQUID TRANSFER/SPRAYS.

Respiratory Protection:NIOSH APPROVED ORGANIC VAPOR CARTRIDGE
RESPIRATOR IF EXPOSURES WARRANT.
Ventilation:LOCAL EXHAUST: TO MAINTAIN LEVELS < EXPOSURE LIMIT.
Protective Gloves:RUBBER/POLYVINYL ALCOHOL/TEFLON
Eye Protection:CHEMICAL GOGGLES/FACE SHIELD
Other Protective Equipment:AIRLINE RESPIRATOR, SPARK RESISTANT TOOLS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. EXPERT ASSISTANCE FROM A QUALIFIED PROFESSIONAL SHOULD BE
SOUGHT.
Supplemental Safety and Health

Boiling Pt:B.P. Text:208.4F
Vapor Pres:83
Vapor Density:3.4
Spec Gravity:0.688
Evaporation Rate & Reference:(BU AC = 1): >1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR LIQUID W/MILD SWEET ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
OXYGEN & STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, DIRECT SUNLIGHT, IGNITION SOURCES.
Hazardous Decomposition Products:CARBON OXIDES

Waste Disposal Methods:INCINERATE/PLACE IN PERMITTED WASTE MANAGEMENT
FACILITY, IAW/FEDERAL, STATE & LOCAL REGULATIONS. UN1206.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.